I was driving my 2024 Toyota Corolla SE gas model (with the convenience package) on the interstate in [XXX] during stop-and-go traffic. Traffic had been moving slowly for about 15 minutes, and I had Brake Hold turned on, cruise control was off, Proactive Driving Assist was on. I was behind a semi truck and was moving very slowly, getting ready to stop. I had maybe 3 or 4 car lengths between me and the semi so they could see me in their mirrors. As I was about to stop, the brake pedal suddenly went all the way to the floor, the car jerked to a stop, and the electronic/emergency parking brake applied on its own. I put the car into Park and then back into Drive, and the problem did not happen again during that drive. There were no warning lights, dash lights, or warning messages before this happened, and there were also no warning lights or dash lights afterward. The issue happened suddenly with no prior symptoms that I noticed. I believe the brake system, Brake Hold system, electronic parking brake system, or a related brake/vehicle control system malfunctioned. This put my safety and the safety of others at risk because the car unexpectedly stopped abruptly in interstate traffic. Since I was in heavy stop-and-go traffic and other vehicles, there was a risk of being rear-ended, causing a crash, or becoming disabled in traffic. I took the vehicle to a Toyota dealership after the incident. They were not able to reproduce the problem, but they did find stored code C14FE14. They told me they checked the brake system, cleared the code, tested the steering angle sensor connector, and said everything tested within specification. They also performed a multipoint inspection and said the battery, brake pads, and other inspected items tested well. To my knowledge, the vehicle has only been inspected by the Toyota dealership/service center. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While I was driving during the evening time on March 7, 2026, my rear passenger window exploded, for seemingly no reason, as I stepped out of the vehicle I noticed no one around and I called the police and I was given a report number which is 26–01784 and that is with the Westminster police department!

DEFECT: Steering wheel fails to fully return to center after turns, consistently stopping 1/2-1 inch off-center. Minor steering adjustments stick and don't self-correct. Pronounced binding zone near center prevents smooth return. SYMPTOMS: After curves, wheel returns 80% but stops visibly off-center requiring manual correction. Minor lane adjustments stick and require counter-correction. Constant manual steering correction causes driver fatigue. Progressive worsening since purchase. SAFETY: Incomplete return at highway speeds causes drift. Sticking divides attention from hazards. Emergency maneuvers require manual straightening during critical response time. SERVICE: February 2026 - McGovern Toyota technician documented "VEHICLE DID NOT RETURN OR SELF CENTER" but Toyota corporate refused repair claiming "normal characteristic." Had 6+ alignments with no improvement. Recent alignment caused binding to flip sides, proving internal mechanical binding not alignment issue. RELATED: Toyota issued CSP 22TE02/TSB T-SB-0028-22 (2022) for 2018 Camry with identical "reduced return to center" caused by intermediate shaft binding. My 2024 Corolla has same defect Toyota acknowledged in 2018 models but refuses to repair. INDUSTRY PATTERN: Honda HR-V TSB 24-094 (2024), Mazda CX-90 Recall 24V-022 (26+ failed fix complaints, 2 crashes), GM Bolt TSB 17-NA-148, Ford Explorer ST owner reports - all for steering not returning to center. REQUEST: Investigate if Toyota intermediate shaft defect extends to 2024 Corolla and whether industry-wide EPS binding represents systemic safety issue. Toyota confirmed defect in writing but denies repair.

One part of the strap is 3/4 of the way frayed

The contact owned a 2024 Toyota Corolla. The contact stated that while the vehicle was stopped on a curb with another vehicle approximately 8 -10 feet ahead, the brake pedal was depressed to shift into park; however, the vehicle independently accelerated. The contact stated that because of the failure, the contact's vehicle rear-ended the Honda CR-V vehicle that was parked in front of the contact's vehicle. The contact stated that the vehicle's speed was only 3–4 MPH. No air bags deployed. The other vehicle sustained damage to the rear bumper. The contact's vehicle was towed to a local tow yard. The contact's vehicle was condemned as a total loss by the insurance adjuster. No police report was filed. No injuries were sustained. The manufacturer was made aware of the failure. The failure mileage was approximately 10,000.