I would welcome making my vehicle available for inspection on this issue. Year/Make/Model: 2023 Kia Sportage EX HEV AWD 4-Door SUV Color: Black Powertrain: Hybrid Electric Vehicle (HEV) Number of occupants: 2 (driver and passenger) Injuries: None, but fatalities could have occurred. Vehicle turned off completely – no power, no hazard lights, and although driver miraculously made it to the shoulder, most of it was blocked by a snowbank and sat in a dead car with no hazard lights. Passenger (recovering from leg surgery in full leg brace) was forced to exit onto a snow bank and enter a tow truck cab, risking re-injury. Crash: No — vehicle was somehow brought to shoulder and aid protected by two state trooper vehicles until a tow arrived. Our car suddenly emitted a loud alarm at highway speed on I-84 -the instrument panel displayed an "stop vehicle immediately" warning. There was no prior warning, unusual noise, or dashboard indication of any problem. The car shut completely down while still on the highway. Car was towed to the nearest KIA dealer - Columbia Ford/Kia [XXX] ). After diagnosis, the authorized Kia dealer documented the following on Repair Order Invoice W7403: • Concern: "TOW IN. DIED WHILE DRIVING. SEPARATED" • Diagnostic fault code: BMS P1BB20 • Failed/replaced parts: ◦ DECOUPLER-BASFILTR, Part No. SPO 25290 2MHD0 ◦ BOLT-CRANKSHAFT, Part No. KIA 23127 2MHA0 ◦ BATTERY MODULE ASSY, Part No. SPO 37507 L5000 • Parts total: $835.54 • Vehicle in dealer possession: March 5, 2026 – March 20, 2026 (15 days) complete loss of motive power at highway speed. Based on my subsequent research, this failure mode appears consistent with a documented similar issue in the United Kingdom and European markets - which did result in a recall. -hybrid belt/tensioner system. Kia issued revised parts and ECU updates in those markets. No equivalent safety recall or consumer notification has been issued in the US. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.

Ev battery system threw up back back to earnings and codes of overcharge and then all lights on dash came on started beeping and then dash went red saying check hybrid system , hybrid system failure stop vehicle. Engine wouldn’t kick back on. I had literally just left my local Kia for a routine checkup and there report is nothing is wrong. Even tho I’ve called them now a few times about it shaking and idling super hard and going limp very often. Towed back to Kia and they have now had it for 4 days and still no results.

On October 3rd, 2025 I was driving at approximately 15mph when my dash started to flash red while beeping. It displayed a message that stated "Check Hybrid System" Within 15 seconds the car shut off. There was no power to utilize the flashers to warn drivers behind me. The abrupt stop caused a near collision and left my car stranded in an intersection. After about 5 minutes I was able to utilize the 12v battery reset button and get the car safely to the side of the road. My car had an all points inspection in September and no issues were noted at that time. I searched 3 websites, including NHTSA, and all noted I had 0 recalls on my vehicle. However, there were multiple reports of this happening to other 2023 Kia Sportage owners over the past 2 years. Some reported that this happened to them on the highway. On October 6th, 2025 I took my car to the dealership to be serviced. Upon check-in the advisor stated I had 2 active recalls on my vehicle. (Safety Recall: Hybrid Control Unit Sw Upgrade (vesc) OEM code SC322 from January 2025 and Saftey Recall: Bms S/w Upgrade (vesc) OEM Code SC338 from June 2025) The first recall has to do with emissions, the second causes the exact scenario that happened to my vehicle. My concern is that Kia failed to report all affected VIN numbers, or failed to notify all affected customers within 60 days reporting the recall as mandated by the NHTSA and they should be held responsible for that. A car shutting off within 10 seconds could be catastrophic when traveling on busy highways. This could result in multiple injuries or even fatalities and needs to be further investigated.

I will be driving 70mph on the freeway and suddenly the "check hybrid system" alert flashes and I have about 20 seconds to safely pullover. Once stopped it will not drive over 5-10 mph for about a half a mile, then completely dies. If I jump start it, it will start, but the car is limited to ~40mph and may not start again once turned off. Has been to the Kia dealership three times in the past month and they say there are no codes to fix regarding the Hybrid battery or system and keep returning it to us. It is exceedingly dangerous to drive and we are afraid to drive on the highway now.

After driving for roughly 7 hours upon activating my cruise control, after using the entire drive with no issues, it went up to 110 mph as soon as I hit the button and would not allow me to adjust the speed down. It would turn off upon pressing pause, cruise control, or brakes but would rise to 110 mph everytime. I searched for recalls for this and could find none. But I did find posts of other people with the same issue. The only thing I could find was an emissions campaign that seems like it may be related. This appears to me to be much more of a safety issue especially if the driver is not paying attention. Or for example let's say you're driving behind someone and turn cruise control on you could very easily rearend someone at a high rate of speed. I will be trying to get my car into the dealership to try and resolve the issue, but my main point for filing a report is to see if this rises to the level of a safety recall versus a tsb or emissions campaign. My vehicle is available for inspection if needed. No warning lights came on or anything of the sort. I do have a video of this but does not appear I can upload it. Any assistance is greatly appreciated thank you and have a great day