In normal operation on Tuesday May 26,2026, the engine experienced catastrophic failure. The engine is the GM L87 6.2 Liter. This was on a highway in the country and I was able to maneuver the truck off the road before an accident occurred. It did leave me stranded and I was required to get it towed on a roll off (It was not drivable) to the dealer where I purchased it. The dealer [XXX] ) inspected my truck and has informed me that the issues with my 2025 Sierra match the issues for the recall GM had for the model years 2021-2025. It will require a new engine, radiator, among many other parts. There weren't any previous warnings. A check engine light only came on once the engine was engine came apart. An oil change on the vehicle by GM was done a month ago. The truck is a 2025 and has approximately 6,600 miles is all. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

6.2L crankshaft failed

15000 miles and the engine spun a bearing and the engine blew

My GMC sierra AT4 with the 3.0L Duramax Diesel, has 1,500 miles on it, when the engine failed. I was traveling from [XXX] to [XXX] , towing a trailer, when the check engine light came, and the truck entered reduced power mode. It immediately slowed the truck without warning - which made for a very dangerous situation for all of the vehicles behind me and for my vehicle. After getting the vehicle and trailer to a dealer, disconnecting the trailer, and then getting the truck in the shop, the dealer defined the OBDII code as being P06DD - Engine oil pressure control solenoid valve stuck off. U0146 - Lost communication with central gateway module, and U1605 - Lost communication with side obstacle detection control module - right on private CAN Bus. The dealer indicated that the P06DD code meant that the thrust bearing on the crankshaft failed and the engine would need to be replaced. The ending only has 1500 miles on it. It turns out that there are MANY GM 3.0L diesel engines that have failed for this issue and that GM issued a Technical Service bulletin in 2025 for this issue - TSB 25-NA-307. I work in the medical device industry and when there is a safety issue with your products - you initiate a RECALL. To date there has been no recall simply the TSB. What is the NHTSA going to do about ensuring that GM, and other manufacturers, are making engines safe? These engines can literally explode - sending metal shards through the engine into the passenger compartment. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

First occurrence was 02/27/2026 - onstar detecated a critical issue, the check esc, check tsc words came on in the center dash, then the orange lights came on and my truck went into limp mode at a stop light. I had to limp mode a mile to the nearest dealer. Where nothing was repaired just reset. Second occurrence - exhaust flap valve failed creating chirping noise resulting in a muffler replacement on 04/28/2026 - picked the vehicle up on 04/30/2026 Third occurrence - 05/01/2026 came out after a wedding to start my truck which it immediately repeated the first occurrence, check esc, check tsc with the orange lights and chugging. recorded on camera now the trucks been at the dealership awaiting updates.