I am submitting this complaint to report a persistent safety-related defect in my 2023 Volvo XC40. Since the vehicle was purchased, the infotainment system has repeatedly crashed while the vehicle is in operation, at times as often as every 5 minutes. The condition has existed both before and after completion of the recall/software update, and it was not corrected after presentation to an authorized dealer for inspection and repair. These repeated system failures materially affect the safe operation of the vehicle. When the infotainment system crashes, the rearview camera becomes unavailable. In addition, the windows and windshield may fog up, and I may lose access to the controls needed to restore visibility. The loss of forward visibility, combined with the loss of rear camera functionality, creates a substantial and unreasonable risk to motor vehicle safety. Although I suspect the problem may involve inadequate hardware or processing capacity, I am not asserting a definitive technical diagnosis. The critical fact is that the vehicle repeatedly loses important operational and safety-related functions while being driven. Because the defect persists despite the recall update and dealer intervention, I request that NHTSA investigate this condition as a potential safety defect in the 2023 Volvo XC40.

Driver assist failed and brakes failed when vehicle veered to left on its own..Brakes and steering failed when trying to correct failure.. Overcorrection caused vehicle to veer off road and over a sign and continue for approximately 50 feet. Vehicle is currently at State Farm towing lot. My safety and others were put at risk with "reckless" driving. The problem has not been reproduced. A State Farm claims adjuster will inspect the vehicle today 2/18/26 or tomorrow. No warning lamps or messages appeared.

The contact owns a 2023 Volvo XC40 BEV. The contact stated that after the brake module OTA firmware update, the brakes became inoperable. The OTA update removed the AUTO-HOLD function. While depressing the accelerator pedal, the pedal failed to respond as needed. The "AUTO-HOLD" message was displayed while at a stop sign. While driving up a steep hill and making a turn, the vehicle failed to stop while depressing the brake pedal. The AUTO-HOLD warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the AUTO-HOLD function was no longer available. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 30,000. The VIN was not available.

The contact owns a 2023 Volvo XC40. The contact stated that while reversing, the rearview camera display intermittently was distorted or inoperative. The failure occurred on several different occasions. The contact stated that the infotainment system was intermittently inoperative and had to be manually reset to return to normal operation. The contact stated that the Forward Collision Avoidance: Automatic Emergency Braking and the Back Over Prevention: Automatic System Braking independently activated while there were no vehicles or objects in front or behind the vehicle. The contact was concerned that the failure was causing emotional distress for him and his children and could eventually cause an injury. The failure had occurred on several occasions. The contact stated that the rear taillights were dim and failed to provide adequate illumination behind the vehicle while in reverse. No warning lights were illuminated. The vehicle was taken to a dealer for diagnosis; however, the dealer stated that the vehicle was operating as designed. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the vehicle was performing normally. The failure mileage was unknown.

The contact owns a 2023 Volvo XC40. The contact stated while the vehicle was parked, the front passenger's side seat belt failed to latch as intended. The contact's mother was attempting to latch the front passenger's side seat belt when the failure occurred. The contact stated that the failure could have occurred while the vehicle was being driven. The vehicle was taken to the dealer to be diagnosed; however, the contact was not provided the result of the diagnostic test. In addition, the contact stated that four months prior to the failure, the front driver's side seat belt failed to latch as intended. The vehicle was taken to the dealer where it was determined that there was a failure with the latching mechanism. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 5,000.